咨询热线:15833324666
主营产品: 电动葫芦,CD1钢丝绳电动葫芦,MD1钢丝绳电动葫芦,行车钢丝绳电动葫芦等各种型号起重设备。

24小时全国服务热线

0312-8496919

如果您有任何疑问或是问题,请随时与我们联系

查看联系方式>>
钢丝绳电动葫芦资讯 当前位置:钢丝绳电动葫芦 > 新闻资讯 > 钢丝绳电动葫芦资讯 >

钢丝绳电动葫芦减速机加什么油?

时间:2019-05-06 17:21    点击量:

CD1/MD1钢丝绳电动葫芦减速机加什么油?每三个月一次,自上部注孔注入齿轮油HL-10或机械油HJ-50。各吨位电动葫芦添加量为:0.25吨钢丝绳葫芦加0.2升,0.5吨钢丝绳葫芦加0.75升,1吨钢丝绳葫芦加0.75升,2吨钢丝绳葫芦加1.5升,3吨钢丝绳葫芦加1.7升,5吨钢丝绳葫芦加2.5升,10吨钢丝绳葫芦加3升,16吨钢丝绳葫芦加3升。

1、

CD1/MD1 wire rope electric hoist reducer add what oil? Once every three months, inject gear oil hl-10 or mechanical oil hj-50 from the upper injection hole. The addition amount of electric hoist of each tonnage is: 0.25 tons of wire rope hoist plus 0.2 liters, 0.5 tons of wire rope hoist plus 0.75 liters, 1 ton of wire rope hoist plus 0.75 liters, 2 tons of wire rope hoist plus 1.5 liters, 3 tons of wire rope hoist plus 1.7 liters, 5 tons of wire rope hoist plus 2.5 liters, 10 tons of wire rope hoist plus 3 liters, 16 tons of wire rope hoist plus 3 liters.

电动葫芦减速机

2、

钢丝绳电动葫芦减速机为何加油?(Wire rope electric hoist reducer why oil?)

减速箱或轴承需要定期更换润滑油,如果没有按要求润滑,减速机不仅会产生过高的噪声,还会过度磨损或损坏齿轮及轴承,严重的会导致物料坠落情况。在设备操作时有人认为减速机暂时不加或随便加点润滑油,照样能运转,不会发生严重故障,这种思想是错误的。有客户反馈操作员初次使用没有阅读说明书,没有按要求给减速机内加注润滑油,在使用过程中产生很大的响声,并出现物料坠落,经后期检查打开减速箱,发现齿轮磨损过度报废,减速轴承损坏,出现异响。这种情况需返厂拆卸检修或更换,解决故障,消除噪音。

3、

Gearbox or bearing needs to change the lubricating oil regularly. If not lubricated as required, the reducer will not only produce excessive noise, but also excessively wear or damage the gear and bearing, which will seriously lead to material fall. In the operation of equipment, some people think that the reducer can still operate without adding lubricating oil temporarily or casually, without serious failure. This idea is wrong. According to the customer feedback, the operator did not read the instruction for the first time and did not add lubricating oil into the reducer as required. In the process of using the reducer, there was a lot of noise and falling of materials. After opening the reducer box after the later inspection, it was found that the gear was excessively worn out, the reducer bearing was damaged and abnormal sound occurred. This kind of circumstance needs to return the factory to dismantle overhaul or change, solve breakdown, eliminate noise.

电动葫芦减速机

4、

钢丝绳电动葫芦减速机为何漏油?(Wire rope electric hoist reducer why oil leakage?)

(1)密封失效;(2)箱体变形;(3)剖分面不平;(4)连接螺栓松动;电动葫芦减速器漏油处理措施:(1)更换密封件;(2)检修箱体剖分面,变形严重则更换;(3)剖分面铲平;(4)清理回油槽,紧固螺栓。

(1) seal failure; (2) box deformation; (3) uneven split surface; (4) loose connection bolts; Electric hoist reducer leakage treatment measures :(1) replace the seal; (2) check the box body section surface, and replace it if the deformation is serious; (3) section plane leveling; (4) clean up the oil groove and tighten the bolts.

电动葫芦减速机

5、

此外在设备检修时,由于结合面上污物清除不彻底,或密封胶选用不当、密封件方向装反、不及时更换密封件等也会引起漏油。加油量过多:减速机在运转过程中,油池被搅动得很厉害,润滑油在机内到处飞溅,如果加油量过多,使大量润滑油积聚在轴封、结合面等处,导致泄漏。减速器内外的压力差较大:减速器运行转动过程中,运动摩擦发热以及受外界环境温度的影响,使减速器温度升的过高,如果没有透气孔等出气地方,则起重机机内压力逐渐增加,机内温度也会越高,与外界的压力差便会越大,润滑油在压差作用下,从缝隙处漏出。

6、

In addition, in the maintenance of equipment, due to the combination of surface dirt removal is not complete, or improper selection of sealant, sealing parts of the direction of reverse, not timely replacement of sealing parts will also cause oil leakage. Too much oil: in the running process of the reducer, the oil pool is stirred very badly, and the lubricating oil is splashed everywhere in the machine. Reducer pressure difference inside and outside is bigger: running in the process of the rotational speed reducer, motor friction heat and influenced by the environment temperature, reduce the temperature rise is too high, if there is no air holes vent place, such as increasing pressure on the crane machines, machine temperature will be higher, the greater the pressure difference with the outside world will, lubricating oil under the action of pressure difference, the leakage from the gap.

电动葫芦减速机

7、

友情提示 (Helpful hints)

严禁超载、斜拉、钢丝绳电动葫芦作业时下面严禁站人或作业,使用前请加润滑油。设备随机附有控制箱、限位器接线说明书,钢丝绳电动葫芦安装前请认真阅读。

Overload, cable-stayed, wire rope electric hoist operation is strictly prohibited to stand below or operation, please add lubricating oil before use. The equipment is attached with the wiring instruction of control box and limit device. Please read it carefully before installation.

【返回列表页】
地址:河北省保定市清苑区东闾工业区河北悍象起重机械有限公司  电话:赵经理(同微信):158-3332-4666  张经理(同微信):133-3122-1310  
传真:0312-5954166    ICP备案编号:冀ICP备17022359号-1    主营产品:电动葫芦,手拉葫芦,手扳葫芦,升降平台,起重吊篮,镀锌吊篮,简易龙门架等
网站地图阿拉伯水烟日精电机
河北悍象起重机械有限公司